Category Archives: Fiberglass Skylights

Kalwall & Fiberglass Skylights

Kalwall Skylights Kalwall skylights are made with FRP, or fiber-reinforced polymers, commonly known as fiberglass. All fiberglass constructed skylights require maintenance. Cleaning the skylights periodically is helpful in removing pollution and light-blocking dirt from the exterior surface. Fiberglass skylights have an exterior gelcoat that helps reduce damage from UV rays, but this wears away over time. It … Continue reading Kalwall & Fiberglass Skylights

Fiber Bloom

Kalwall Fiber Bloom Fiberglass skylights are protected from the elements by a coating sometimes referred to as “gel coat”. The coating has a UV blockage component to help prevent the sun’s rays from damaging the fiberglass and causing fiber bloom. Fiberglass Gel Coat Unfortunately the coating applied to the exterior of the skylights by the … Continue reading Fiber Bloom

Polycarbonate Wall Lights

Comparison between a failed fiberglass wall light and newly installed polycarbonate wall light. Note the difference in light between the polycarbonate wall lights on the right compared to the fiberglass wall light on the left. The amount of light from the new CPI Wall Lites was unbelievably brighter than the old fiberglass wall lites. Michael … Continue reading Polycarbonate Wall Lights

Retrofit Skylights

Many fiberglass skylights are failing and need replaced Many architects, contractors, insurance adjusters, engineers, forensics specialists and building maintenance people are discovering the deterioration of fiberglass skylights. Fiberglass is protected from the suns damaging UV rays by a gel coat. Unfortunately, the gel coat only lasts 10-15 years and then the fiberglass begins to fall apart, allowing water and … Continue reading Retrofit Skylights

Satellite Images of Monumental Skylight Replacements

A before and after picture of a skylight in Charlotte, North Carolina Before Pictures of old cruddy looking fiberglass skylight that was only sixteen years old. Maintenance people had to shut down the top floor because of the out-gassing of putrid smell through the fiberglass skylight. Replaced with polycarbonate barrel vaults, manufactured by CPI. Search … Continue reading Satellite Images of Monumental Skylight Replacements

Heat Loss Through Fiberglass Skylights

Another example of problems with fiberglass skylights The picture in this blog post shows a fiberglass skylight with a light covering of snow. Notice how all snow is melted at the grid lines. The reason for this is because the aluminum that is located on the inside of the panel is not thermally broken and … Continue reading Heat Loss Through Fiberglass Skylights

Texas Skylight Repair

Texas is close enough to Colorado to allow Skylight Specialists, Inc. to perform commercial skylight repairs Texas is a big state, as we all know, but close enough to Colorado to allow us to travel there by vehicle to perform commercial skylight repairs. There are many commercial monumental skylights in need of repairs including rusted … Continue reading Texas Skylight Repair

Fiberglass Skylight Replacement

Another Kalwall Fiberglass Replacement We will soon be replacing another fiberglass skylight where the owner is complaining of a horrid “fish-type” smell in their interior spaces. The gel-coat on the skylights have deteriorated and the fiberglass is fiber blooming. This allows water to penetrate the outer layer of fiberglass and it enters into the middle … Continue reading Fiberglass Skylight Replacement